I Hope Pjay Wasn't involved

Talk About Everything Else...
Sports, Toys, The Weather, etc.
User avatar
Challenge
Donator 08','09,'10,'11,'12,'13,'14,'15,'16,'17,'18'
Posts: 301
Joined: Wed Jun 18, 2008 6:08 pm
Location: MA & RI

I Hope Pjay Wasn't involved

#1

Post by Challenge » Thu Apr 09, 2015 6:50 pm

From WorkBoat Magazine :shocked:

A bad day on the water

Bruce Buls
4/9/2015

Until about noon on July 29, 2014, everything was working normally on the Tacoma, a Jumbo Mark II ferry owned by Washington State Ferries and carrying passengers and vehicles between Seattle and Bainbridge Island.

At 11:59 a.m., the #4 propulsion alternator of the boat’s diesel-electric system was started to provide additional power during a landing in Seattle. After the landing, while the engineers were removing #4 alternator from service, a voltage surge caused an alarm to sound for .92 seconds. The engineering crew doesn’t know why the alarm went off and apparently thought it was insignificant. It wasn’t.

After unloading, the Tacoma departed Seattle bound for Bainbridge Island. All systems appeared to be working normally. They weren’t.


When #4 alternator was activated to assist the landing on Bainbridge, all hell broke loose. An “arc event” in the transformer cubicles melted copper bus work and damaged electrical conductors. Surge arrestors in alternator cabinets were destroyed, and the heat deformed steel supports. Steel switchboard covers were pushed out due to high pressure inside. Smoke came into the engine room. Individual visual and audible alarms, 110 of them, were triggered. The diesel engines running #3 and #4 alternators shut down.

In-port and emergency generators started automatically and power for the steering system and onboard lighting was restored, but a power management system opened and closed a breaker 35 times in four minutes, banging loudly each time.

As vessel speed dropped due to power failures, the captain turned north to avoid grounding, thanks to power from the emergency generator. At the same time, cooling water pumps weren’t working and engines began to overheat.

At 12:58 p.m., the master dropped anchor to prevent the ferry from drifting into the beach.

By 14:19, the ferry has been towed by the Lindsey Foss and the Pacific Knight to the Bainbridge Island terminal where all vehicles and passengers were offloaded.

This timeline and the many other details about the power failure that day are all included in the recently released Board of Inquiry report that can be found here. It’s fascinating reading.

In the end, the board concluded that “the root cause was a feature of the propulsion control system, namely the phase loss relay, which allowed the #4 alternator circuit breaker to connect or close when it should not have been allowed to energize the circuit, causing loss of propulsion.”

After eight months of inspecting and rebuilding the diesel-electric propulsion system, the Tacoma finally returned to service on March 28.

Chaps
Donator '09
Posts: 2138
Joined: Sun Jan 13, 2008 12:19 am
Location: Seattle, WA

Re: I Hope Pjay Wasn't involved

#2

Post by Chaps » Thu Apr 09, 2015 8:10 pm

This all happened right below my house (see pic). I have not read the report you sited (I will) but a couple of things in the post are a bit off. The Tacoma did end up practically on the beach (see pic) and the boat that was mainly responsible for getting it out of harms way was the smaller ferry Sealth who came to the rescue off of its Bremerton/Seattle run. Sealth nosed in, threw Tacoma a line and dragged it out into deeper water before the tide stranded her. When the Foss tug finally got there they got all lashed up and started to pull the Tacoma to Seattle to unload the cars and passengers until the captain on the Tacoma jumped on the VHF and yelled at the Foss captain "where the hell you going?!"

Seems the Foss captain thought the passenger load on the Tacoma needed to go to Seattle but fact was Tacoma had just come from Seattle and everyone and the cars on Tacoma needed to off-load at Bainbridge! Good communications bridge-to-bridge there (I heard all this as I have a vhf in my house that I was monitoring). So now what to do, the big Foss tug is pulling the Tacoma backwards and due to shoals in the area they were going to have a tough time getting things turned around. Luckily there was a small trailing tug hooked up that was there to swing the Tacoma when steerage was needed so the little tug ended up being the big dog pulling not only Tacoma but the huge Foss tug into Eagle Harbor to the ferry terminal . . . it was such a screwed up mess . . . the tourists on the boats had a great time seeing this all unfold. If you look at the very top of the pic you can see a good sized boat heading in the general direction of the mayhem, that is the Lindsey Foss coming to the rescue . . . hah!
tacoma sealth.jpg
1987 24' LaConner pilothouse workboat, 225 Suzuki
Image
please view and like: https://www.facebook.com/bottompainting/

Post Reply Previous topicNext topic